Rv Awning Motor Maintenance

Tips to maintain your rv awning.

Rv awning motor maintenance.

Electric rv awning operation is simple enough and easy to maintain. Protect your rv awning from the damaging effects of uv radiation. The manual advises using a mixture of cup bleach cup dishwashing liquid added to 5 gallons of water. Rub down the rails pulley rollers and retracting arm to make sure they are not sticking due to friction rust or dirt.

I disassembled the control panel and swapped the slide out room switch it uses the same switch with the power awning switch and the fault swapped as well. Our large 21 foot dometic 9100 rv power awning is made out of vinyl and has held up very well after 4 years of full time rving. There can be several reasons for that and a repair man should be able to check on that. This told me the motor and wiring to the awning was good.

If the awning is not appropriately set the chances of getting new tears and holes will increase significantly. Always let the awning air dry don t use heaters. Step 3 fix warped rails. By doing this the motor should start to operate and extend or retract the awning.

Repairing the rv awning power switch. Ultraviolet rays from the sun will also take their toll on your awning. To wash your rv awning simply hose it off. I tried the awning using it and it worked.

You re just trying to get the dirt off not deep clean the awning. Solera awning motor wires remove the 3 bolts that hold the motor in place using a 10mm wrench or socket. While you are attaching your awning make sure not to take the end caps out. Keep the water temperature less than 100 degrees fahrenheit.

There is no purpose to take them out unless you want to replace the awning. If that does not happen then the motor has gone bad. One way to repair a motorized awning is to simply lubricate the working parts with some machine oil. Don t remove end caps.

Remove the bad motor and replace it with the new one. Inspect pull strap slide pins rv awning motor if its electric awning. You yourself can replace most parts of the awning apart from few things like fabric and awning arms. I generally clean it every few months by following the procedure outlined in the owner s manual.

Here are seven tips for regular rv awning maintenance.